1.格遵守安全操作規程，不準違章作業或酒后作業。
2.正確使用勞動保護用品，高處作業系好安全帶。
3.吊架內側距建筑物為10—20cm，兩個吊籃的間距不得大于20cm。
4.吊籃設單層、雙層兩種，每層高度不得大于2m，而寬度不大于1m。
5.懸掛吊籃的挑梁必須固定牢固，可用預埋錨固體與屋面構件固定，也可用配重壓牢。但必須用腳手桿將挑梁連為整體，配重有固定的容器(砂袋、鐵籠、箱子)承裝。
6.吊籃的外側和端部應設兩道防護欄板，高度不少于1.5m并滿掛圍網或不低于18cm的擋腳板。
7.吊架必須與建筑物連接牢固不得搖晃，上下吊架要設固定通道。
8.懸掛吊籃的挑梁，其支點以內的長度和挑出長度之比應大于3。且挑梁應外高里低。
9.支撐腳上板的橫向水平桿間距：當采用3cm厚木板時，不應大于50cm，跳板不得探頭并鎖牢。
10.吊籃與挑梁必須用鋼絲繩連接，纏繞挑梁不得少于三圈，不得綁扣，必須用3個以上卡子固定。
11.每個吊籃必須備兩根保險繩，每次升降后要將保險繩與吊籃固定牢固。
12.采用機具升降吊籃時，其使用機具(手搬葫蘆、斤不落、吊車、鐵扁擔等)必須滿足荷載要求并按說明進行操作。
13.使用中嚴格控制荷載，并隨時清除吊籃內的雜物。
14.工作中發現不安全因素，可暫停作業，并立即上報。
中譯英：
1 grid observe the rules for safe operation, no illegal operations or drunk operation.
2 the proper use of labor protection supplies, high operating fasten safety belt.
3 inner side of the hanger from the building for10 20cm, two baskets of distance not greater than 20cm.
4 single, double basket set two, the height of each layer is not more than2m, and the width is not more than 1m.
5 hanging basket cantilever beam must be fixed firmly, can be embedded anchor solid and roof components can also be pressed firmly fixed, counterweight. But must use the foot lever will pick of Liang Lian as a whole, weight is fixed to the container ( bag, cages, box ) for loading.
6 baskets of the lateral and end should be provided with two protective board, a height of not less than1.5m and hanging over a fence or not less than 18cm block feet.
7 hanger must be firmly connected with buildings shall not be shaken, upper and lower hanger to set fixed channel.
8 hanging basket cantilever beam, its pivot point within the length and trajectory length ratio should be greater than 3. And cantilever beam should be high in low.
9 support foot plate on the horizontal bar spacing: when using 3cm plank, should not be larger than50cm, springboard not probe and locking.
10 basket and cantilever beam must be connected with a wire rope winding, cantilever beam of no less than three rings, not tied to buckle, must use more than 3clips.
11 each of the barrel must be prepared two insurance rope, each lifting to the safety rope and the hanging basket is fixed firmly.
12 the equipment lifting cradle, the use of tools ( hand hoist, Jin does not fall, crane, iron pole etc. ) must meet the load requirements and follow the instructions.
13 the use of strict control of the load, and at any time to clear the sundries in the basket.
14 found in the work of safety factor, can be suspended operations, and report immediately.
(圖/文http://www.chinaketong.com.cn) |
